Продукт болееview
The Blodgett DFG-200 ADDL is a gas-fired convection oven designed for commercial kitchen environments. It features digital controls, a ceramic interior, and a stainless steel exterior, offering efficient and consistent baking and roasting capabilities. This single-deck unit has a capacity for five 18" x 26" pans per compartment.
Изображение: Спереди view of the Blodgett DFG-200 ADDL Convection Oven. It is a stainless steel unit with two glass doors on the front, revealing multiple racks inside. The Blodgett logo is visible above the left door. The unit stands on four stainless steel legs.
Информация по безопасности
Always adhere to local and national codes for installation and operation. Ensure proper ventilation and gas connections are made by qualified personnel. Disconnect power before servicing. Keep area clear of combustible materials.
- Перед использованием духовки внимательно ознакомьтесь со всеми инструкциями.
- Не храните и не используйте бензин или другие легковоспламеняющиеся пары и жидкости вблизи этого или любого другого прибора.
- Установка и обслуживание должны выполняться квалифицированным установщиком, сервисной службой или поставщиком газа.
- Ensure adequate clearance around the oven for proper airflow and maintenance.
Настройка и установка
Распаковка
Carefully remove the oven from its packaging. Inspect for any shipping damage. Report any damage to the carrier immediately. Retain packaging materials for potential return or future transport.
Требования к местоположению
The oven must be installed on a level, non-combustible surface. Ensure sufficient clearance from walls and other equipment for ventilation and service access. Refer to local codes for specific clearance requirements.
Подключение газа
A qualified gas technician must connect the oven to the gas supply. The oven requires a 60,000 BTU gas supply. Ensure all connections are leak-tested before operation.
Электрическое подключение
The oven requires a 1/2 HP electrical connection for the fan and controls. Ensure the electrical supply matches the oven's requirements and is properly grounded. Consult a qualified electrician for installation.
Вентиляция
Proper ventilation is crucial. The oven must be installed under an exhaust hood that complies with local and national fire and safety codes. Ensure the flue connector is properly installed.
Инструкция по эксплуатации
Контрольный список перед операцией
- Ensure gas and electrical supplies are connected and active.
- Verify the oven interior is clean and free of debris.
- Check that the oven racks are properly seated.
Initial Startup (Burn-Off)
Before first use, operate the oven empty at 450°F (232°C) for at least one hour to burn off any manufacturing oils or residues. This may produce some smoke and odor; ensure the area is well-ventilated.
Цифровое управление
The DFG-200 ADDL features solid state digital controls for precise temperature and time management. Familiarize yourself with the control panel:
- Температурный регулятор: Регулирует желаемую температуру приготовления.
- Циферблат таймера: Устанавливает продолжительность приготовления.
- Переключатель скорости вентилятора: Selects between two fan speeds for different cooking applications.
- Oven Light Switch: Activates the interior light for visibility.
Процедура приготовления
- Preheat the oven to the desired temperature using the temperature dial. The indicator light will turn off when the set temperature is reached.
- Place food items on appropriate baking pans and load them into the oven. The oven accommodates five 18" x 26" pans per compartment.
- Close the simultaneous operated doors securely.
- Установите время приготовления с помощью циферблата таймера.
- Monitor cooking progress through the glass doors and adjust fan speed as needed.
- When cooking is complete, open the doors carefully to allow steam to escape before removing food.
Техническое обслуживание и очистка
Regular maintenance ensures optimal performance and extends the life of your Blodgett DFG-200 ADDL oven.
Ежедневная уборка
- Перед очисткой дайте духовке полностью остыть.
- Протрите внешнюю поверхность из нержавеющей стали с помощьюamp ткань и мягкое моющее средство. Избегайте абразивных чистящих средств.
- Clean the porcelain interior with a non-abrasive oven cleaner or a solution of baking soda and water. Rinse thoroughly.
- Remove and clean oven racks with warm, soapy water.
Weekly/Monthly Checks
- Inspect door gaskets for wear and tear. Replace if damaged to maintain heat efficiency.
- Check the interior light bulb and replace if necessary.
- Ensure the fan motor area is free of grease buildup.
Профессиональное обслуживание
It is recommended to have the oven professionally inspected and serviced annually by a qualified technician. This includes checking gas connections, burner operation, and electrical components.
Руководство по устранению неполадок
В этом разделе представлены решения распространенных проблем. Для решения проблем, не указанных в списке, обратитесь к квалифицированным специалистам сервисной службы.
| Проблема | Возможная причина | Решение |
|---|---|---|
| Не греет духовка | No gas supply; Electrical issue; Pilot light out (if applicable); Faulty igniter. | Check gas valve; Verify power supply; Relight pilot (refer to specific instructions); Contact service technician. |
| Неравномерное приготовление | Improper loading; Fan malfunction; Door gasket leak. | Ensure even pan spacing; Check fan operation; Inspect and replace door gasket if damaged. |
| Чрезмерное количество дыма/запаха | Food spills; Initial burn-off; Improper ventilation. | Clean oven interior thoroughly; Ensure adequate ventilation during burn-off; Check exhaust system. |
| Digital controls unresponsive | Power interruption; Control panel fault. | Reset circuit breaker; Contact service technician. |
Технические характеристики
- Модель: DFG-200 ADDL
- Тип: Gas Convection Oven, Single-Deck
- Емкость: (5) 18" x 26" pans per compartment
- Управление: Solid State Digital
- Вентилятор: 2-х скоростной
- Интерьер: Фарфор
- Экстерьер: Stainless Steel (front, sides & top)
- Двери: Simultaneous operated with glass
- Ноги: 6" Stainless Steel
- Двигатель: 1 / 2 HP
- БТЕ: 60,000 БТЕ
- Размеры (упаковка): Approximately 38.25" x 36.88" x 32" (L x W x H)
- Масса: Примерно 565 фунтов
- Сертификации: cETL, NSF
Гарантия и поддержка
For warranty information and technical support, please refer to the documentation provided with your purchase or contact Blodgett customer service directly. Ensure you have your model number (DFG-200 ADDL) and serial number ready when contacting support.
Blodgett Customer Service: Visit Blodgett Support Webсайт
