Введение
This manual provides comprehensive instructions for the safe and efficient operation, installation, and maintenance of your Blodgett CTB Double Electric Half Size Double Deck Convection Oven. Please read this manual thoroughly before operating the oven to ensure proper use and to prevent potential hazards.
Image: The Blodgett CTB Double Electric Half Size Double Deck Convection Oven. This image displays the two-deck oven unit, typically shown with a stand, featuring dual control panels and large glass doors for each oven cavity.
Информация по безопасности
Always adhere to the following safety precautions to prevent injury or damage to the oven:
- Электробезопасность: Ensure the oven is connected to a properly grounded electrical supply of the specified voltage. Disconnect power before servicing.
- Горячие поверхности: Oven surfaces become extremely hot during operation. Use caution and wear protective gloves when handling hot items or cleaning.
- Вентиляция: Ensure adequate ventilation around the oven to prevent overheating and to dissipate cooking fumes.
- Уборка: Always allow the oven to cool completely before cleaning. Use only recommended cleaning agents.
- Уполномоченный персонал: Only qualified and authorized personnel should perform installation, maintenance, and repairs.
Настраивать
Before initial operation, ensure the following steps are completed:
- Распаковка: Carefully remove all packaging materials. Inspect the oven for any shipping damage. Report any damage immediately to the carrier and supplier.
- Размещение: Position the oven on a level, stable surface. Ensure sufficient clearance from walls and other equipment for proper ventilation and access. The oven includes a 19-inch stainless steel stand and vent riser.
- Электрическое подключение: A qualified electrician must connect the oven to the appropriate electrical supply. Refer to the specifications section for voltagэлектронные требования. Note: Specify voltage when placing order.
- Первоначальное выгорание: Before first use, operate the oven empty at 350°F (177°C) for approximately 30 minutes to burn off any manufacturing oils. Ensure the area is well-ventilated during this process.
Инструкция по эксплуатации
The Blodgett CTB Double Convection Oven is designed for efficient and even cooking. Each deck operates independently.
Контролируетview:
- Контроль температуры: Solid state thermostat with a temperature range of 200°F to 500°F (93°C to 260°C).
- Таймер: Solid state timer for precise cooking duration.
- Переключатель вентилятора: Controls the 2-speed, 1/4 HP convection motor.
- Выключатель: Включает/выключает духовку.
Основная операция:
- Предварительный нагрев: Turn the power switch ON. Set the desired temperature using the temperature control knob. Allow the oven to preheat until the indicator light turns off, signaling the set temperature has been reached.
- Загрузка продукта: Open the dual pane thermal glass windows in the stainless steel door frames. Carefully place baking pans on the chrome-plated racks. The oven accepts 13 in x 18 in half size baking pans front to back. There are 5 racks for 9 positions with a minimum of 1 5/8 in spacing per cooking section.
- Установка времени приготовления: Set the desired cooking time using the solid state timer.
- Скорость вентилятора: Select the appropriate fan speed (high or low) based on the product being cooked.
- Мониторинг: Monitor cooking progress through the glass doors. Avoid opening the doors frequently to maintain oven temperature.
- Завершение: When cooking is complete, the timer will signal. Carefully remove the cooked product.
- Неисправность: Выключайте выключатель питания, когда он не используется.
Обслуживание
Regular maintenance ensures optimal performance and extends the life of your oven.
- Ежедневная уборка:
- Дайте духовке полностью остыть.
- Wipe down interior and exterior stainless steel surfaces with a damp тканью и мягким моющим средством.
- Clean the dual pane thermal glass windows with a glass cleaner.
- Remove and clean the chrome-plated racks.
- Чистка салона: The oven features a double sided porcelainized baking dimensions liner for easier cleaning. For stubborn stains, use a non-abrasive oven cleaner as directed by the product manufacturer.
- Двигатель вентилятора: The 1/4 HP convection motor has automatic thermal overload protection. Ensure the fan area is kept clear of debris.
- Периодическая проверка: Regularly inspect door gaskets for wear and tear. Replace if damaged to maintain heat efficiency. Check electrical cords for any signs of damage.
Поиск неисправностей
Refer to the following table for common issues and their solutions. For problems not listed or if issues persist, contact qualified service personnel.
| Проблема | Возможная причина | Решение |
|---|---|---|
| Не греет духовка | Отсутствие электропитания; сработал автоматический выключатель; неисправен нагревательный элемент. | Check power connection and circuit breaker. Contact service for element replacement. |
| Неравномерное приготовление | Improper loading; fan motor issue; faulty thermostat. | Ensure proper air circulation around pans. Check fan operation. Contact service for thermostat. |
| Oven fan not working | Fan motor overload; wiring issue; faulty motor. | Allow motor to cool (automatic thermal overload). Check wiring. Contact service for motor replacement. |
| Чрезмерное количество дыма/запаха | Food spills; initial burn-off; residue from cleaning agents. | Clean oven thoroughly. Ensure proper ventilation during initial burn-off. Rinse cleaning agents completely. |
Технические характеристики
| Особенность | Деталь |
|---|---|
| Модель | CTB Double |
| Бренд | Блоджетт |
| Тип | Electric Half Size Double Deck Convection Oven |
| Размеры (Ш x Г x В) | 30 1/4 in (W) x 25 1/8 in (D) x 69 1/8 in (H) (approx. 30.5"D x 25.5"W x 69.1"H) |
| Масса | 595 фунта |
| Емкость кастрюли | Accepts 13 in x 18 in half size baking pans front to back |
| Стойки | (5) chrome plated racks for (9) positions with minimum of 1 5/8 in spacing per cooking section |
| Диапазон температур | от 200°F до 500°F (от 93°C до 260°C) |
| Мотор | 2-speed, 1/4 HP convection motor with automatic thermal overload |
| Строительство | Full angle iron frame, Stainless steel front, top & sides, Dual pane thermal glass windows, Double sided porcelainized baking dimensions liner |
| Включенные аксессуары | 19 in stainless steel stand & vent riser |
| Сертификаты | ETL listed, NSF certified, Energy Star rated |
Гарантия и поддержка
Your Blodgett CTB Double Electric Half Size Double Deck Convection Oven comes with the following warranty:
- Гарантия на детали: 2 года
- Гарантия на работу: 1 год
- Oven Door Warranty: Ограниченная гарантия 5 года
For technical support, service requests, or warranty claims, please contact Blodgett customer service or your authorized dealer. Ensure you have your model number and purchase date available when contacting support.
For more information, visit the official Blodgett webПосетите сайт или обратитесь к местному дистрибьютору.
