Dapper Supply DP-WBFS1218 20-inch Walk-Behind Floor Scrubber Polisher User Manual

1. Введение

This manual provides essential instructions for the safe and efficient operation, maintenance, and troubleshooting of your Dapper Supply DP-WBFS1218 Battery Powered Walk-Behind Floor Scrubber Polisher Machine. Please read this manual thoroughly before operating the machine to ensure proper use and to prevent injury or damage.

The Dapper Supply DP-WBFS1218 is designed for commercial floor cleaning, offering a 20-inch cleaning path, powerful scrubbing, and efficient drying for various hard floor surfaces.

2. Инструкции по технике безопасности

ВНИМАНИЕ: Несоблюдение данных инструкций по технике безопасности может привести к серьезным травмам или повреждению имущества.

• Always read and understand the entire manual before operating the machine.
• Ensure the machine is turned off and unplugged (if charging) before performing any maintenance, cleaning, or adjustments.
• Do not operate the machine in areas with flammable liquids, gases, or dust, as this may cause fire or explosion.
• Keep hands, feet, and loose clothing away from moving parts, especially the brush and squeegee.
• Use only approved brushes, pads, and cleaning solutions.
• Do not wash the operation panel with water.
• Charging should be carried out in a well-ventilated area, away from high temperatures and direct sunlight.
• When the brush plate is running, do not park the machine for a long time.
• Wear appropriate personal protective equipment (PPE) such as non-slip footwear and eye protection.
• Не допускайте к работе с машиной детей или неподготовленный персонал.
• Always operate on stable, level surfaces. The machine supports inclines up to 20 degrees, but caution is advised.

3. Продукт закончилсяview

The Dapper Supply DP-WBFS1218 is a robust walk-behind floor scrubber designed for commercial use. Key features include:

• 20-inch Cleaning Path: Efficiently covers large areas with a 20-inch cleaning width and a 31.5-inch squeegee for streak-free drying.
• Heavy Brush Pressure: 66 lbs of brush pressure combined with a 200 RPM brush motor for deep scrubbing and removal of tough grime.
• Высокая производительность: Cleans up to 27,000 sq ft/hr, suitable for warehouses, retail, schools, and commercial buildings.
• Strong Vacuum System: 170 kPa suction and a 500W vacuum motor ensure floors are dry in seconds.
• Large Dual Tanks: Features a 14.5-gallon solution tank and a 17-gallon recovery tank for extended cleaning sessions.
• Long Runtime & Efficient Charging: Powered by a 24V / 85Ah battery, providing 3-4 hours of runtime per charge with an 8-hour full recharge cycle.
• Convenient Spray Hose: Integrated rear spray hose for spot cleaning, with a 0.92 ft reach and 22 lbs pressure.
• Тихая работа: Работает с низким уровнем шума — 60 дБ.
• Универсальный: Supports operation on inclines up to 20 degrees.

Компоненты

Familiarize yourself with the main components of your floor scrubber:

Рисунок 3.1: Общий view of the Dapper Supply DP-WBFS1218 Walk-Behind Floor Scrubber Polisher Machine.

Рисунок 3.2: Сторона проfile of the floor scrubber, showing the main body and handle.

Рисунок 3.3: Передний view of the floor scrubber, highlighting the brush assembly.

Рисунок 3.4: The robust construction of the Dapper Supply floor scrubber, built for durability.

4. Настройка

1. Распаковка: Осторожно извлеките машину и все принадлежности из упаковки. Осмотрите её на предмет повреждений, полученных при транспортировке.
2. Зарядка аккумулятора:
   • Connect the charger to the machine's charging port and then to a suitable power outlet.
   • Allow approximately 8 hours for a full charge. The battery provides 3-4 hours of runtime.
   • Ensure charging is done in a well-ventilated area.
3. Attaching the Brush/Pads:
   • Убедитесь, что машина выключена.
   • Align the brush or scouring pad (3 included) with the brush plate and secure it firmly.
   

   Рисунок 4.1: Крупный план view of the brush assembly, showing how brushes or pads are attached.

4. Заполнение бака с раствором:
   • Open the cap of the 14.5-gallon solution tank.
   • Fill with water and an appropriate, non-foaming cleaning solution according to the manufacturer's instructions. Do not overfill.
   

   Рисунок 4.2: Filling the 14.5-gallon solution tank with water and cleaning solution.

5. Adjusting the Squeegee: Ensure the 31.5-inch squeegee is properly positioned and adjusted for optimal water recovery.

5. Инструкция по эксплуатации

1. Запуск машины:
   • Вставьте ключ в замок зажигания и поверните его в положение «ВКЛ».
   • The control panel will illuminate.
2. Engaging Scrubbing and Vacuum:
   • Press the brush button to start the 200 RPM brush.
   • Press the vacuum button to activate the 170 kPa suction system.
   • Отрегулируйте рукоятку до удобной рабочей высоты.
   

   Рисунок 5.1: Operator using the Dapper Supply floor scrubber for cleaning.

3. Процедура очистки:
   • Walk behind the machine at a steady pace, allowing the brush to scrub and the squeegee to recover the dirty solution.
   • The 20-inch cleaning path ensures efficient coverage.
   • For heavily soiled areas, a second pass may be required.
4. Using the Integrated Spray Hose:
   • To use the spray hose for spot cleaning or pre-treating, press the "Water gun button" located on the side panel.
   • Direct the spray nozzle towards the desired area.
   

   Рисунок 5.2: Utilizing the integrated spray hose for targeted cleaning.

5. Остановка машины:
   • Release the handle and turn the key to the OFF position.
   • Ensure all functions are disengaged.

6. Техническое обслуживание

Regular maintenance ensures the longevity and optimal performance of your floor scrubber.

1. После каждого использования:
   • Резервуар для сбора сточных вод: Empty the 17-gallon recovery tank. Rinse it thoroughly with clean water.
   • Чистящий скребок: Inspect and clean the squeegee blades. Replace if worn or damaged.
   • Clean Brush/Pads: Remove and rinse the brush or pads. Allow them to air dry.
   • Протирочная машина: Очистите машину снаружи с помощью рекламного средства.amp ткань.
2. Уход батареи:
   • Recharge the battery after each use, regardless of remaining charge, to maximize battery life.
   • Не допускайте частой полной разрядки аккумулятора.
3. Регулярные проверки:
   • Check all hoses and connections for leaks or damage.
   • Убедитесь, что все крепежи надежно затянуты.

7. Поиск Неисправностей

This section provides solutions to common issues. For problems not listed here, contact Dapper Supply support.

8. Технические характеристики

9. Гарантия и поддержка

Your Dapper Supply DP-WBFS1218 Floor Scrubber is backed by a 1-летняя гарантия на детали и работу.

For technical assistance, parts availability, or warranty claims, please contact Dapper Supply's U.S.-based support team. Refer to your purchase documentation for contact details or visit the official Dapper Supply webсайт.